2024年3月22日发(作者：迈巴赫汽车报价大全)

Owner’sManual

with Installation Instructions

Banks

?

Monster

Exhaust

System

2001-2007 (LB7, LLY & LBZ) Chevy/GMC 6.6L

Duramax Turbo-Diesel Pickups

THIS MANUAL IS FOR USE WITH SYSTEM

48628-48634, 48937-48941

Gale Banks Engineering

546 Duggan Avenue ? Azusa, cA 91702

(626) 969-9600 ? Fax (626) 334-1743

Product Information & Sales: (800) 438-7693

?2008 Gale Banks Engineering

09/15/08 PN 96408 v.9.0

General Installation Practices

1.

Before starting work, familiarize

2.

The exploded view (Figure 1)

yourself with the installation procedure

by reading all of the instructions.

provides only general guidance. Refer

to each step and section diagram in

this manual for proper instruction.

left side of the vehicle refers to the

driver’s side, and the right side to the

passenger’s side.

cable from the battery (or batteries, if

there are two) before beginning work.

minimum of 6” away from exhaust

heat, moving parts and sharp

edges. clearance of 8” or more is

recommended where possible.

lubrication system components while

performing the installation, as foreign

objects will cause immediate engine

damage upon start-up.

Tools Required:

?

1

?

2

” and

3

?

8

” drive ratchets with

standard and metric sockets and

1

?

2

”

and

3

?

8

” drive extension

? Standard and metric combination

or open-end wrenches

? Standard screwdriver

? Clean shop towels or rags

? Pry-bar

Highly recommended tools and

supplies:

? Foot-pound torque wrench

? Penetrating oil or light lubricant

spray

3.

Throughout this manual, the

4.

Disconnect the negative (ground)

5.

Route and tie wires and hoses a

6.

When raising the vehicle, support

it on properly weight-rated safety

stands, ramps or a commercial hoist.

Follow the manufacturer’s safety

precautions. Take care to balance the

vehicle to prevent it from slipping or

falling. When using ramps, be sure the

front wheels are centered squarely on

the topsides; put the transmission in

park; set the hand brake; and place

blocks behind the rear wheels.

Caution! Do not use floor jacks to

support the vehicle while working

under it. Do not raise the vehicle

onto concrete blocks, masonry

or any other item not intended

specifically for this use.

7.

During installation, keep the work

area clean. Do not allow anything to

be dropped into intake, exhaust, or

2

96408 v.9.0

更多推荐

汽车报价,系统,作者,排气